CTEK XS 800 XS800 BATTERY CHARGER CAR BIKE BOAT MARINE

Features

• Four step, fully automatic switch mode model.
• Charges lead-acid batteries (Wet, MF, GEL and AGM) from 1.2Ah to 32Ah, 1.2-100Ah maintenance charging.
• Maintenance pulse charging increases battery life and gives superb performance.
• Charges even drained batteries.
• Pulse recover of slightly sulphated batteries.
• Low back current drain, low ripple and input voltage independent (170-260V).
• High efficiency: 85%
• Delivered with two interchangeable connection leads, one with clamps, and one with eyelet terminals.
• The charger can be connected for months, ideal for seasonal vehicles.
• Compact design with mounting holes for permanent assembly.
• 5 year warranty.

The XS 800 has a fully automatic, four step charge:

Desulphation
Runs a complete charge cycle within a fraction of a second. The cycle repeats during the whole desulphation phase. Every cycle recovers some lead sulphate into useful material.

Bulk
Charging where 80% of the energy is returned. The charger delivers a constant current until the battery voltage has reached the set level.

Absorption
Final part of the charge up to 100%. The battery voltage is kept constant at the set level, during which time the current drops gradually.

Pulse
Maintenance charging. The state of charge varies between 95% and 100%. A pulse is sent out to the battery if the voltage drops. This keeps the battery in trim when not in use. The charger can be connected for months at a time.

Using the XS 800 gives your battery an optimum service life and operational reliability.

Equipment

The XS 800 is delivered with two different battery leads, one with clamps and one with eyelet terminals, all colour coded for easy +/- identification.

If the battery is difficult to access, the lead with eyelet terminals can be mounted to the battery, and the quick connectors are located so that it is easily reached for charging.

You can also purchase additional leads allowing you to have one lead with eyelet terminals fixed to all your vehicles with batteries that are difficult to get at, and charge them simply from the same charger.

Technical Data

MODEL	XS 800
Input voltage AC	170-260VAC, 50-60Hz
Output voltage	Nominal: 12V
Efficiency	85%
Charging voltage	14.4V
Charging current	0.8A max
Back current drain	<1mA
Ripple	10mV rms, 12mA (2%)
Ambient temperature	-20°C to +50°C, output power is reduced automatically at higher temperatures.
Type of charger	Four step, fully automatic switch mode with pulse maintenance.
Type of batteries	12V lead-acid batteries (Wet, MF, AGM and GEL)
Battery capacity	1.2-32Ah (1.2-100Ah maintenance charging)
Dimensions (L x W x H)	142x51x36mm
Insulation	IP 65 (splash and dust proof)
Weight	0.3kg

Batteries

The XS 800 charges lead-acid batteries (Wet, MF, GEL and AGM) from 1.2Ah to 32Ah. You will find an explanation of the various battery types under Charger University, Battery Types.

The charger can also be used for maintenance charging of 12V lead-acid batteries from 1.2Ah to 100Ah.

The XS 800 is easy to use. You do not need to make any settings. The charger adapts the charge to suit the battery and switches to pulse maintenance charging when the battery is fully charged.

BULK CHARGE TIME
BATTERY SIZE (Ah)	FOR ABOUT 80% CHARGE (h)
2	2
8	8
20	20
60	60
100	>80

Safety

• Electronic safe, the charger will not damage vehicle electronics. The battery does not normally need to be disconnected from the vehicle when charging.
• Minimal gas build-up and a patent-pending spark protection system.
• Short circuit and reverse polarity protected.
• Double insulation.
• Splash and dust proof (IP65) and approved for outdoor use.
• Progressive temperature protection.
• Tested and approved by Intertec SEMKO AB. S-marked and conforms to the following standards: EN 60335-1, EN 60335-2-29, EN 55014-2, EN 55022, EN 61000-3-2 and EN 61000-3-3

Mounting

• The charger is easily fitted in place using two screws. The diameter of the mounting holes is 4.2mm located as shown in the image. The image also shows the dimensions of the charger.